wayground logo

Free Printable Worksheets

Font size

S
M
L
XL
Worksheets

Chassis L2

Total questions: 14

Worksheet time: 7mins

Name
Class
Date
1.

Which of the following is a special tool required for removal of steering knuckle off the driveline?

a)

Jack Stand

b)

Chisel

c)

Tie rod ball remover

d)

Punch and hammer

2.

which of the following symptoms require release bearing refitting of the hectors manual transmission

improper gear shifting

a)

improper gear shifting

b)

hard gear shifting

c)

odd gear not engaging

d)

damaged drive shaft oil seal

3.

if the lower arm ball joint Bush is having cuts, then__________

a)

ball joint push needs to be replaced

b)

ball joint assembly needs to be replaced

c)

sealant should be applied to the Bush

d)

entire lower arm needs to be replaced

4.

The steering wheel of the gloster vibrates. Which of the following component of the suspension system will you inspect?

a)

Power steering motor

b)

steering rack

c)

RHS sparing knuckle assembly

d)

intermediate shaft

5.

select the special tool used while replacing DCT clutch assembly of hector.

a)

CH-0030 puller

b)

CH- 0226 seal plate oil seal guide tool

c)

PT- 0092 Chuck

d)

Both A and B

6.

Which of the following symptoms requires a major overhaul of the CVT transmission of the hector.

a)

Hard gear shifting

b)

Odd gear or not engaging

c)

oil leakage at the differential housing and drive shaft

d)

transmission MIL on cluster

7.

Select the correct special tool used to install transfer case front flange oil seal

a)

C00089920

b)

C00089924

c)

C00089921

d)

C00089927

8.

Replacement of the__________ requires major over overhauling of the hectors steering system.

a)

Steering gear

b)

Replacement of flexible rubber sleeve

c)

Replacement of inner tie rod half steering leakage

d)

Steering wheel

9.

Which of the following is cause for rattle, clunk, pop or shudder noise in the steering system of the hector.

a)

Faulty steering rack gear

b)

Faulty flexible rubber sleeve

c)

Faulty dustproof rubber sleeve

d)

Faulty steering lock

10.

What is the last step after replacing the outer tie rod of steering leaking of the hector.

a)

Fix both the wheels back

b)

Connect back the negative cable to the battery terminal

c)

Check wheel alignment

d)

None of the above

11.

when installing the steering wheel of the gloster, ensure the steering column is matched with the__________key slot of the steering wheel.

a)

Rectangular

b)

Circular

c)

Triangular

d)

None of the above

12.

A hector tends to sway while taking corners. Which of the following component of the suspension system will you check?

a)

Stabilizer link rod

b)

Rare twist beam

c)

Suspension spring

d)

Both A and B

13.

Astor’s outer ball joint is fixed to the front lower control arm by________

a)

2 bolts and nuts

b)

5 bolts and nuts

c)

4 bolts and nuts

d)

3 bolts and nuts

14.

inspection of which of the following component of the manual transmission system does not require the transmission to be disconnected from the engine?

a)

Shifter cable

b)

hydraulic release bearing

c)

diaphragm spring

d)

odd gear not engine