Worksheetse-Golf
Total questions: 26
Worksheet time: 13mins
How do you determine a battery's classification (Safe/Critical/Dangerous)?
It is coordinated through a VTA
You must call the QTM
It is not necessary for most shipping
Your Service Manager or Warranty Admin.
Batteries classified as "Critical" do not require special shipping containers if it's quarantined long enough.
True
False
All the e-Golf's de-energizing test plans are the same.
False
True
What is the function of the e-Golf Maintenance Connector?
It grounds the "Pilot Line" to T31
It opens the "Pilot Line" and the power supply to the HV contactor control circuits
It opens the "Pilot Line" and locks the charge port flap
It opens T30C by applying a ground
The Heat Pump cannot be used below 0°C (32°F).
False
True
Sort of
What does the e-Golf's Heat Pump use to heat the interior?
G12 coolant
G13 coolant
Refrigerant
A high voltage PTC heater grid
The liquid coolant inside the HV battery (AX2) is regulated to what temperature?
80°C (176°F)
72°C (161.6°F)
It's not regulated, it just circulates with a support pump
There is no liquid coolant inside AX2
The e-Golf selector lever can be moved from park if a charging cable is connected, but charging is complete.
False
True
Which is not a function of JX1?
Converting external charging HVAC to HVDC for charging AX2
Converting HVAC from VX54 to HVDC for charging AX2
Converting AX2's HVDC to HVAC that is supplied to VX54
Transforming AX2's HVDC to LVDC for the 12V battery
How quickly can the transistors in JX1 switch?
Picoseconds
Microseconds
30 times a second
Nanoseconds
What happens after the "hand shake" when charging with an external HVAC source?
Cell balancing
The vehicle begins charging
There is a 1000V pulse sent to check integrity of the source
There is a 750V pulse sent to check insulation resistance of the charge cable
What is the "Pilot Line"?
It is a single-wire circuit that runs through all HV components.
It is used for "Park Pilot" to send the ultrasonic sensor data to J533
It's the phone number to arrange a private Cessna tour
It is the communication wire between UX4 and AX4
How does the "Pilot Line" function?
If it goes "close-circuit", J840 opens the HV contactors.
If it goes "open-circuit", J840 opens the HV contactors.
An Electrically Aware Person (EIP) can replace and service HV components.
True, but only after an HVT has de-energized the vehicle
True, but only after the Shop Foreman says it's okay
False. You have to be an HVT to replace all HV components
False. You must be an HVE to replace all HV components
Your skin's resistance at voltages greater than 100V is:
0Ω
500Ω
1080Ω
Skin is always 0Ω
Some orange cables on the e-Golf are not HV.
True
False
Which is the correct order of the 3 steps of HV safety during repairs?
De-energize, secure against re-energization, verify the absence of voltage
Verify the absence of voltage, de-energize, secure against re-energization
Secure against de-energization, get coffee, smoke break
We didn't talk about that
The on-board battery charger (AX4) provides the HVDC for DC Fast Charge.
False
True
If the ECO+ drive mode is manually selected, it is still possible to go over 56 mph.
True
False
Which company manufacturers the e-Golf's generator, motor, transmission, and HV battery?
Valeo
Bosch
VW
Takata
What will the initial MEB platform ranges be?
125-135 miles
132-247 miles
248-373 miles
83-125 miles
How many EVs does VW plan to have on-the-road by 2028?
1,000,000
22,000,000
100,000
10,000,000
Which MEB vehicle will arrive in the American market in 2020?
ID. CROZZ
ID. Buzz
ID.
ID. R
When does VW plan to discontinue the production of internal combustion engine vehicles?
There is currently no plan to to discontinue it
2050
2040
2030
Which was the first BEV Volkswagen model available to the public?
Type 1
MK1 Golf
MK7 Golf
Type 2
Which was the first generation of e-Golf?
The MK1
The MK2
The MK3
The MK4
